粉料撒布车比人工撒布好在哪里？_新闻中心-山东途畅路桥工程有限公司

热门关键词： 550冷再生机 600冷再生机租赁 250S租赁冷再生机强夯机出租

新闻中心

首页>>新闻中心粉料撒布车比人工撒布好在哪里？

新闻中心

新闻资讯

联系我们

山东途畅路桥工程有限公司

联系人：石总

电话：18264104888

地址：山东省济南市槐荫区经一路273号群盛华城

粉料撒布车比人工撒布好在哪里？

来源：http://www.tclqgc.com/ 日期：2019-11-20 发布人：

如今人工成本的愈发高涨，还有对于环境保护的重视，用粉料撒布车替代人工撒布就已经成为了一个必然的趋势，那么使用撒布车比人工好在哪里呢？施工成本能够降低多少呢？下面小编就来讲解一下。

　　Nowadays, the labor cost is increasing, and the state attaches great importance to environmental protection. It has become an inevitable trend to replace manual spreading with powder spreader. What is the better use of spreader than manual operation? How much can the construction cost be reduced? Let's talk about it.

　　粉料撒布车比人工撒布好在哪里？

　　What are the advantages of powder spreader than manual spreader?

　　以开展20cm厚混凝土就地冷再生为例，混凝土使用量5%，约再造5000，每日要用混凝土量115吨，花费比较如下：

　　Taking 20 cm thick concrete in situ cold recycling as an example, the concrete consumption is 5%, about 5000 square meters is recycled, and the daily concrete consumption is 115 tons. The cost comparison is as follows:

　　人工铺摊：人工工资3000,25人，薪水120，柴油机费200，拖拉机400，混凝土花费36800等等，终总花销40400。粉料撒布车：人工200，混凝土34500，柴油机费240，终总成本34940。

　　Manual paving: 3000, 25 people, 120 salary, 200 diesel engine fee, 400 tractor, 36800 concrete cost, etc., and the final total cost is 40400. Powder spreader: Labor 200, concrete 34500, diesel engine cost 240, final total cost 34940.

　本推算假设了混凝土使用量相同，效率一样等前提，实际上在真实的运用过程中粉料撒布车还会存有以下两方面的优点：

　　This calculation assumes that the concrete consumption is the same and the efficiency is the same. In fact, in the actual application process, the powder spreader will have the following two advantages:

　　1、机器设备洒布与再生机同步，进而减小了混凝土的损失，通常较人工洒布能够降低0.5%的混凝土消耗量，即用人工洒布时混凝土实际上控制使用量要较理论掺入量提升1%，而用机器设备洒布控制提升0.5%即可；

　　1. In general, the concrete consumption can be reduced by 0.5% compared with manual spraying, that is to say, when using manual spraying, the actual control consumption of concrete should be increased by 1% compared with the theoretical mixing amount, while the control amount with machine equipment can be increased by 0.5%;

　　2、机器设备洒布要较人工效率高，每一小时的洒布总面积就达到4000，经可供应5台冷再生同时作业。因效率的提高，单位总面积内所包含的机械设备费与人工费都会大幅度减少，为顾客节约成本。

　　2. The spraying efficiency of machinery and equipment is higher than that of labor. The total area of spraying per hour is 4000 square meters, which can supply 5 sets of cold regeneration at the same time. Due to the improvement of efficiency, the cost of mechanical equipment and labor in the unit area will be greatly reduced to save costs for customers.

　　以上就是关于粉料撒布车对比人工撒布所具有的优势分析了，相信大家都能够看出撒布车的优势所在了。

　　The above is the analysis of the advantages of powder spreader compared with manual spreader. I believe everyone can see the advantages of spreader.

上一条：路面冷再生机的组成和工作原理！

下一篇：冷再生机可以在哪些方面进行施工？上一篇：冷再生机在公路养护中作用